our products

D&Q Mining is a high-tech company integrating R&D, production and sales. It provides mature products and solutions such as crushers, sand making, milling equipment, mobile crushing stations, etc., for aggregate, mining and waste recycling.

concrete and quarry dust and journal

Use of Quarry Dust to Replace Sand in Concrete An

International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 1 ISSN 2250-3153 ijsrp Use of Quarry Dust to Replace Sand in Concrete

More

Concrete And Quarry Dust And Journal

Use of Quarry Dust to Replace Sand in Concrete An Experimental Study329 Кб. For this concrete mix, quarry dust was added for replacement of sand from 0% to in step of 10%. ijsrp International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 ISSN 2250-3153 2 B...

More

(PDF) Use of Quarry Dust to Replace Sand in Concrete An

The Quarry dust may be used in the place of river sand fully or partly.A comparatively good strength is expected when sand is replaced partially or fully with or without concrete admixtures.It is proposed to study the possibility of replacing sand with locally available crusher waste without sacrificing the strength and workability of concrete.

More

Partial Replacement of Sand by Quarry Dust in Concrete

Quarry dust can be defined as residue, tailing or proportions of cement concrete + quarry dust (M 20, AND M25). other non-voluble waste material after the extraction and The experimental results showed that the addition of quarry dust processing of rocks to form fine particles less than 4.75mm. as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties.

More

Introduction to Quarry-Dust as Partial IJERT Journal

Quarry dust can be used as an admixture in concrete efficiently to lessen its impact on environment and human. It can also be used as partial replacement of cement in concrete. Cement can be replaced partially by quarry dust in percentage by weight like 10%,15%,20%,25%,30%,35%,40% and 50%.

More

USE OF QUARRY DUST IN CONCRETE AS REPLACEMENT FOR

construction work. Quarry dust is produced from crusher unit and each crusher unit is produced nearly 22% to 27% of dust. This dust is completely waste material for crusher unit but quarry dust is useful for construction work as sand. If we mix quarry dust in sand then only 65% to 75% of sand replaced by quarry dust because strength of concrete is

More

Use of Quarry Dust to Replace Sand in Concrete An

International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 1 ISSN 2250-3153 ijsrp Use of Quarry Dust to Replace Sand in Concrete An

More

(PDF) Use of Quarry Dust to Replace Sand in Concrete An

A. Mix proportioningTwo grades of concrete M20 and M25 having nominal mix proportion of 1:1.5:3 and 1:1:2 respectively were used by weight and w/c ratio was fixed according to the slump requirement of 60mm. For this concrete mix, quarry dust was added for replacement of

More

Effect of Quarry Dust on High Performance Concrete

3.4 Quarry Dust The quarry dust used for this investigation work is obtained from the quarry near tindivanam in Tamil Nadu. The quarry dust passing through 4.75 mm retained on 150 micron IS sieves are taken. Specific gravity of 2.617 and fineness modulus of 2.706 has been used. 3.5 Silica Fume The specific gravity of silica fume is 2.2.

More

USE OF QUARRY DUST IN CONCRETE AS REPLACEMENT

construction work. Quarry dust is produced from crusher unit and each crusher unit is produced nearly 22% to 27% of dust. This dust is completely waste material for crusher unit but quarry dust is useful for construction work as sand. If we mix quarry dust in sand then only 65% to 75% of sand replaced by quarry dust because strength of concrete is

More

Study on Compressive Strength of Quarry Dust as Fine

The partial replacement of quarry dust gave a 28 days’ peak compressive strength at 40% replacement level and decreases for 50% replacement. Figure 3 shows the compressive strength relation for both normal concrete and quarry dust concrete, at the age of 28 days for M30, M25, and M20 grades of concrete for different w/c ratios of 0.45 and 0.5.

More

(PDF) Suitability of Quarry Dust as Partial Replacement

There are other studies related to analysis of influence of tailings and/or quarry dust in concrete and are also appreciated [9][10][11] [12] [13] The objective of this study was to analyze the

More

[PDF] Use of Quarry Dust to Replace Sand in Concrete An

This experimental study presents the variation in the strength of concrete when replacing sand by quarry dust from 0% to 100% in steps of 10%. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature. Also the temperature effect on concrete cubes at 100 o C on

More

[PDF] Utilization of Quarry Dust in Cement Concrete Paver

@inproceedings{Sharma2017UtilizationOQ, title={Utilization of Quarry Dust in Cement Concrete Paver Blocks for Rural Roads}, author={P. Sharma and M. Sharma}, year={2017} } P. Sharma, M. Sharma Published 2017 Solid unreinforced pre-cast cement concrete paver blocks is a versatile, aesthetically

More

An Experimental Investigation on Properties of Concrete by

Dec 12, 2017 Various combination of GGBS and Quarry Dust were prepared using M30 Grade of Concrete.The effect on these replacement materials on Compressive Strength, Split Tensile Strength, Flexural Strength, Modulus of Elasticity and Water Absorption were studied and the results obtained were compared with the Control Concrete.

More

Quarry Dust Uses in a Construction Project Concrete Blocks

Jun 06, 2016 Quarry dust a by- product from crushing process during quarrying activities is good alternative during construction projects. It is used as substitute to sand to make quarry dust concrete which is believed to be stronger and more durable than the regular concrete materials. Uses of Quarry Dust. It can be used as substitute to sand wholly or partly.

More

(PDF) A Review on Green Concrete ResearchGate

Sivakumar and Prakash. M. "Characteristic studies on the Mechanical Properties of Quarry Dust addition in conventional concrete", Journal of Civil Engineering and Construction Technology, October

More

Properties of Micro Fine Quarry Dust Concrete

the title of the work and journal citation in the form of a proper scientific referencing. PROPERTIES OF MICRO FINE QUARRY DUST CONCRETE NUR HANANI ABDUL RAHIM1*, KARTINI KAMARUDDIN2, HAMIDAH MOHD SAMAN3 1, 2, 3 Universiti Teknologi MARA (UiTM), Shah Alam, Selangor, Malaysia Index Terms Micro Fine Quarry Dust Cement Replacement Compressive Strength

More

INTERNATIONAL JOURNAL OF CIVIL ENGINEERING

This study explores the strength behavior of concrete mixes with and without quarry dust. The various percentage of quarry dusts such as 10 percent to 45 percent were used to partially replace sand and cement in concrete mixes.Wood ash tested had significant variations in its chemical

More

Comparison of physical and mechanical properties of river

This study compared the physical and mechanical properties of river sand concrete with quarry dust concrete. The constituent materials were batched by weight. The water-cement ratio and mix ratio selected for the experimental investigation were 0.55 and 1:2:4, respectively. The specimens were cured for 7, 14, 21 and 28 days.

More

Effect of Quarry Dust on High Performance Concrete

3.4 Quarry Dust The quarry dust used for this investigation work is obtained from the quarry near tindivanam in Tamil Nadu. The quarry dust passing through 4.75 mm retained on 150 micron IS sieves are taken. Specific gravity of 2.617 and fineness modulus of 2.706 has been used. 3.5 Silica Fume The specific gravity of silica fume is 2.2.

More

Characteristic studies on the mechanical properties of

was studied with various proportions of quarry dust (CM 1:3, CM 1:2, and CM 1:1). The experimental results showed that the addition of quarry dust for a fine to coarse aggregate ratio of 0.6 was found to enhance the compressive properties as well as elastic modulus. Key words: Concrete, quarry dust, fillers, elastic modulus, compressive strength.

More

[PDF] Use of Quarry Dust to Replace Sand in Concrete An

This experimental study presents the variation in the strength of concrete when replacing sand by quarry dust from 0% to 100% in steps of 10%. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature. Also the temperature effect on concrete cubes at 100 o C on

More

An Innovative Method of Replacing River Sand by Quarry

quarry dust. as . replacement . for sand . has been su. p. por. t-ed in the pr. e. vious study (Manassa, 2010) [5] showing that up to 20% of sand has been effectively replaced by quarry dust in traditional concrete. Ilangovan et al. (2008) [9] reported that the strength of quarry rock dust concrete was comparably 10-12% more than that of

More

Comparison of physical and mechanical properties of river

This study compared the physical and mechanical properties of river sand concrete with quarry dust concrete. The constituent materials were batched by weight. The water-cement ratio and mix ratio selected for the experimental investigation were 0.55 and 1:2:4, respectively. The specimens were cured for 7, 14, 21 and 28 days.

More

An Experimental Investigation on Properties of Concrete by

Dec 12, 2017 Various combination of GGBS and Quarry Dust were prepared using M30 Grade of Concrete.The effect on these replacement materials on Compressive Strength, Split Tensile Strength, Flexural Strength, Modulus of Elasticity and Water Absorption were studied and the results obtained were compared with the Control Concrete.

More

Studies on Fresh and Hardened Properties of Recycled

Title: Studies on Fresh and Hardened Properties of Recycled Aggregate Concrete with Quarry Dust Author(s): Revathi Purushothaman and Sasikala Mani Publication: Materials Journal Volume: 111 Issue: 3 Appears on pages(s): 283-290 Keywords: quarry dust; recycled aggregate concrete; resource conservation recycled aggregate Date: 5/1/2014 Abstract: Recycled aggregate obtained from crushed concrete

More

Experimental Study on Partial Replacement of Fine

of concrete by adding quarry dust and red soil with concrete. 5. PREVIOUS STUDY Sumit L (2015) The author says, This paper reports the experimental study which investigated the partial replacement of sand with quarry dust. Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, and M25).

More

quarry waste in concrete pdf

International Journal of Scientific and Research Publications, Volume 5, Issue 7, July 2015 1 ISSN 2250-3153 Partial Replacement of Sand by Quarry Dust in Concrete Sumit L. Chauhan, Raju A.Bondre Assistant Professor P. I. G. C. E. Nagpur Abstract- The paper describe the role of quarry dust In the of various complex silicates are formed, causing

More

Quarry Dust Uses in a Construction Project Concrete Blocks

Jun 06, 2016 Quarry dust a by- product from crushing process during quarrying activities is good alternative during construction projects. It is used as substitute to sand to make quarry dust concrete which is believed to be stronger and more durable than the regular concrete materials. Uses of Quarry Dust. It can be used as substitute to sand wholly or partly.

More

2009,” Properties Of Green Concrete Containing Quarry Rock

An attempt has been made to durability studies on green concrete compared with the natural sand concrete. It is found that the compressive, split tensile strength and durability studies of concrete made of quarry rock dust are nearly 14 % more than the conventional concrete. The concrete resistance to sulphate attack was enhanced greatly.

More

journal of replacement of laterite sand and quarry dust in

journal of replacement of laterite sand and quarry dust in concrete journals of replacement of sand by quarry . journals of replacement of sand by quarry dust in concrete pdf Quarry sand as fine aggregate Construction Aggregate International Journal of Scientific and Research Publications Volume 3 Issue 12 December 2013 ISSN 2250-3153 1 Use of Quarry Dust to Replace Sand in Concrete -journals

More

An Experimental investigation on utilizations of Marble

Hameed M. S. and Sekar A. S. S., Properties of Green Concrete Containing Quarry Rock Dust and Marble Sludge Powder as fine aggregate, ARPN Journal of Engineering and Applied Sciences, Vol. 4, No. 4, June 2009.

More

characteristics of quarry dust BINQ Mining

the characteristics of quarry dust Crusher South Africa. compressive strength of concrete from cement and quarry dust materials. compressive strength of concrete Stone Crusher In India For Concrete is a combination of »More detailed

More